Email this article 
Pengaruh jumlah sekat vertikal dan debit aliran terhadap viskositas oli pada separator air oli
Abstract
Water pollution is a major environment problem. Oil water separator can be used to solve this problem. This research is aimed to get the effect of vertical divider number and fluid flow rate due to oil viscosity. The research is done by experiment using gravity separator. Vertical dividers are varied as 5 and 7. Fluid flow rate is vary as 176,5; 106,6; 53,7 and 33,7 ml/s. Oil 0,5 litre is mixture with 10 litres of water. Oil viscosity is measured with simple flow gravity method. The data is analized statistically using SPSS 17.0. The result shows that vertical divider number and fluid flow rate have effect on oil viscosity.
Full Text:
PDFReferences
Abdulkadir M., Hernandez-Perez V., 2010, The effect of mixture velocity and droplet diameter on oil-water separator using computational fluid dynamics (CFD), World Academy of Science, Engineering and Technology, 61, 35-43.
Agunwamba J.C., Kingsley U., Chinelo O., 2013, Effect of baffles on oil water separator, INT J CURR SCI 2013, 7, 146-152.
Ankyu E., Noguchi R., 2014, Economical evaluation of introducing oil-water separation technology to wastewater treatment of food processing factory based on separation engineering, Agriculture and Agricultural Science Procedia, 2, 67-73.
Anonimous, 2013, Manajemen limbah pada bengkel, http://www.gunadarma.ac.id.
Anshari I, 2013, Limbah minyak, http://www. ans-olahlimbah.blogspot.com.
Aryanti N., Prihatiningtyas I., Wardhani D.H., Ikhsan D., 2013, Kinerja membran ultrafiltrasi untuk pengolahan limbah emulsi minyak-air sintetis, Reaktor, 14(4), 277-283.
Brodkey R.S., Hershey H.C., 1988, Transport phenomena, Erlangga, Jakarta.
Chen L., Wu S., Lu H, Huang K., Zhao L., 2015, Numerical simulation and structural optimization of the inclined oil/water separator, Plos One DOI:10.1371/ journal.pone.0124095, 1-15.
Deshmukh S.R., Jagadeesan P., Chandra A., Raut P., 2013, Bilge oil-water separator, International Journal of Engineering Research & Technology (IJERT), 2(7), 1555-1561.
Jahangiri M.R., Nouri M., 2014, Simulation of three-phase separator in petroleum industry, Journal of Chemical and Pharmaceutical Research, 6(11), 923-936.
Odiete W.E., Agunwamba J.C., 2016, Effect of aspect ratio on the oil separation efficiency of conventional oil/water separators, International Journal of Scientific & Engineering Research, 7(3), 840-846.
Pratiwi K.D.S., Hermana J., 2014, Efisiensi pengolahan limbah cair mengandung minyak pelumas pada oil separator dengan menggunakan plate settler, Jurnal Teknik Pomits, 3(1), D5-9.
Rachman A.M., 2013, Manajemen terhadap limbah bengkel, Fakultas Teknologi Industri, Jurusan Teknik Mesin, Universitas Gunadarma, Depok.
Setiawan T.E., Haeruddin, Ain C., 2014, Efisiensi penggunaan oil water separator pada kapal penangkap ikan untuk pencegahan pencemaran minyak di laut (Studi Kasus KM. Mantis) di BBPPI Semarang, Diponegoro Journal Of Maquares, 3(3), 112-120.
Sutikno S., 2005, Optimasi perancangan model hidraulika untuk memisahkan limbah minyak pada air buangan, Jurnal Sains dan Teknologi, 4(2), 53-57.
Wibowo T.W., Boesono H., Setiyanto I., 2014, Uji performansi alat pemisah limbah cair berminyak (Oily Water Separator) untuk kapal perikanan dalam skala laboratorium, Journal of Fisheries Resources Utilization Management and Technology, 3(4), 1-9.
Zhang X., Cheng Y., Nie S., Ji H., Liu L., 2013, Simulation of multiphase flow of the oil-water separation in a rotating packed bed for oil purification, Hindawi Publishing Corporation Mathematical Problems in Engineering, 1-9.
DOI: https://doi.org/10.29303/dtm.v7i1.5
Refbacks
- There are currently no refbacks.
Copyright (c) 2017 Dinamika Teknik Mesin
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
