Pengaruh generator HHO dan etanol terhadap performa dan emisi gas buang mesin bensin

N.D.C. Setiawan, D.H.T. Prasetiyo, D. Wahyudi

Abstract


The large number of motorized vehicles in Indonesia cannot be separated from the rapid population growth. Fuel is one of the important components in vehicles, this is because the fuel produces heat energy to be converted into mechanical energy. So far, ordinary people only use fuel oil (BBM) based on the price per liter, assuming all fuel can be used in their vehicles. In fact, to get maximum performance and low exhaust emissions, it requires high octane fuel. The purpose of this study was to determine the effect of adding ethanol and HHO to fuel on engine performance and the resulting exhaust emissions. The test sample consisted of Pertamax fuel which was then mixed with 10% ethanol with the addition of HHO. Furthermore, the process of testing the performance of the vehicle's engine and the resulting exhaust emissions. The test results show that there is an increase in power and torque of 7.77 hp and 7.54 N.m, respectively, in the test of fuel mixing with the addition of HHO. Then the results of the exhaust gas test resulted in a decrease in CO and HC while the CO2 level increased by testing the mixing of fuel with ethanol accompanied by the addition of HHO. The average percentage scores for each test were 15.02%, 17.79%, and 16.72%.

Keywords


Power; Torque; HHO; Ethanol; Dynotest

Full Text:

PDF

References


Firnanda, H., Barita, Pengaruh variasi larutan elektrolit pada generator HHO, Jurnal Ilmiah Teknik Mesin, 6(2), 69–76, 2020.

Harman, H., Ahyar, A., Design of HHO generator to reduce exhaust gas emissions and fuel consumption of non-injection gasoline engine, Jurnal Dinamika Vokasional Teknik Mesin, 4(1), 9–17, 2019. https://doi.org/10.21831/dinamika.v4i1.24276

Mara, I.M., Nuarsa, I.M., Alit, I.B., Sayoga, I.M.A., Analisis emisi gas buang kendaraan berbahan bakar etanol. Dinamika Teknik Mesin, 9(1), 45, 2019. https://doi.org/10.29303/dtm.v0i0.258

Mara, I.M., Sayoga, I.M.A., Nuarsa, I.M., Alit, I.B., Wiratama, K., Analisis unjuk kerja motor bensin 4 langkah 1 silinder 100 cc berbahan bakar etanol. Dinamika Teknik Mesin, 10(1), 10, 2020. https://doi.org/10.29303/dtm.v10i1.300.

Mara, I.M., Sayoga, I.M.A., Yudhyadi, I.G.N.K., Nuarsa, I.M., Analisis emisi gas buang dan daya sepeda motor pada volume silinder diperkecil. Dinamika Teknik Mesin, 8(1), 8, 2018. https://doi.org/10.29303/dtm.v8i1.154

Maridjo, Yuliyani, I., Anggani, R., Pengaruh pemakaian bahan bakar premium, pertalite dan pertamax terhadap kinerja motor 4 tak. Jurnal Teknik Energi, 9(1), 73–78, 2019. https://doi.org/10.35313/energi.v9i1.1648

Nofendri, Y., Hidayat, M.F., Qibal, A., Perbandingan Prestasi Mesin dan Emisi Gas Buang Bahan Bakar RON 90 dan RON 92, 9–10, 2019.

Paletekan, J.W., Ajiwiguna, T.A., Pengaruh HHO terhadap emisi dan efisiensi mesin 2 langkah 150 CC, Elektro, F.T., Telkom, U., Nasional, U., 4(1), 821–826, 2017.

Prasetiyo, D.H.T., Wahyudi, D., Analisis pengaruh pipa inner sebagai katalis metanol dengan memanfaatkan energi panas yang terbuang, 5, 7–13, 2022.

Putra, W. T., Malyadi, M., Winardi, Y., Pengaruh gas brown ( HHo ) dengan electrode stainlees terhadap konsumsi bahan bakar, Snttm Xv, 5–6, 2016.

Rhohman, F., Akbar, A., Pengaruh Penambahan Gas HHO Terhadap Emisi Gas Buang Motor 4 Langkah, 2017.

Ruslan, W., Lesmana, I. G. E., Nugraha, K. K., Analisi Performa mesin menggunakan bahan bakar pertalite , pertamax , pertamax turbo terhadap daya dan torsi pada honda beat eSP., Mesin, T., & Pancasila, U., 86–92, 2016.

Satria, G., Yusuf, M., Sumadhijono, P.A., Analisa pengaruh penambahan gas hidrogen dengan atau tanpa pemasangan turbo cyclone terhadap unjuk kerja motor bensin 110 Cc, 1(2), 1–8, 2018.

Sebayang, A.H., Sutrisno, J., Nurulita, B., Ibrahim, H., Perbandingan busi standar dan busi ulti elektroda terhadap kinerja dan emisi gas buang pada mesin bensin, Dinamika Teknik Mesin, 10(2), 144–151, 2020.

Setiawan, Y., Salam, F., Gas hidrogen pada proses elektrolisis terhadap emisi dan konsumsi bahan bakar, Teknik Mesin Untirta, 4(1), 10–13, 2018.

Sholeq, Z.I., Susila, I.W., Analisa kinerja mesin dan emisi gas buang sepeda motor berbahan bakar campuran bioetanol dari ampas tebu dan premium, Journal Teknik Mesin, 07(03), 121–126, 2019.

Wahyono, Anis, R., Pembuatan alat produksi gas hidrogen dan oksigen tipe, Jurnal Teknik Energi, 12(1), 2016. https://jurnal.polines.ac.id/index.php/eksergi/article/view/283/251%0Ahttps://jurnal.polines.ac.id/index.php/eksergi/article/view/283

Wahyudi, D., Prasetiyo, D.H.T., Uji karakteristik pembakaran premixed pada methyl ester schleichera oleosa sebagai campuran bahan bakar diesel, 5, 1–6, 2022.




DOI: https://doi.org/10.29303/dtm.v12i2.518

Refbacks

  • There are currently no refbacks.


Copyright (c)

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

 
 

After being re-accredited, the Journal of Dinamika Teknik Mesin, still has sinta 3 (S3) which is valid until 2025, but certificates and decrees have not been issued.