Peranan medan magnet dan campuran etanol-biodiesel minyak jelantah pada pembakaran droplet terhadap perilaku api dan emisi gas buang

D. Perdana; S.F.W.A. Fiyanto

doi:10.29303/dtm.v14i2.924

Peranan medan magnet dan campuran etanol-biodiesel minyak jelantah pada pembakaran droplet terhadap perilaku api dan emisi gas buang

D. Perdana, S.F.W.A. Fiyanto

Abstract

Petroleum reserves are increasingly depleting, causing a scarcity of petroleum fuel caused by the rapid progress of transportation and the manufacturing industry. This condition forces researchers to search for and develop new renewable energy source. The purpose of research is to understanding and determines role of north-south (U-S) and south-south (S-S) magnetic fields to blend waste cooking oil biodiesel-ethanol on flame evolution, flue gas emissions, and temperature during droplet combustion. Waste cooking oil biodiesel and ethanol were used in this research by adding variations in the direction of repulsive and attractive magnetic fields with an intensity of 11000 gauss. Diameter of droplets tested was 0.3 mm and was placed on a type K thermocouple wire with diameter of 0.1 mm. This research found the role of attractive magnetic field (U-S) in blend waste cooking oil biodiesel-ethanol 20% to produce the shortest flame evolution of 704 ms, lowest CO of 165 ppm, and highest temperature of 828.5 ^oC. This happens because ethanol has a low flash point and large oxygen content, causing the combustion reaction to occur rapidly. The attractive of magnetic field (U-S) plays a role on attracting oxygen around flame to enter combustion reaction, while the H₂O resulting from combustion is pumped out of flame.

Keywords

Waste cooking oil biodiesel, Droplet combustion, Ethanol, magnetic field

Full Text:

PDF

References

Datta, A., Mandal, B.K., Impact of alcohol addition to diesel on the performance combustion and emissions of a compression ignition engine, Applied Thermal Engineering, 98, 670–82, 2016.

Gad, M.S., EL-Seesy, A.I., Radwan, A., He, Z., Enhancing the combustion and emission parameters of a diesel engine fueled by waste cooking oil biodiesel and gasoline additives, Fuel, 269, 117466, 2020.

Gamayel, A., Alshekhly, M.N.A., Al-Zubaidi, S.S., Yusuf, E., Effect of clove oil in droplet combustion of crude jatropha oil, International Journal of Advanced Science and Technology, 29(5s), 1564–1571, 2020.

Ghadikolaei, M.A., Wei, L., Cheung, C.S., Yung, K.F., Effects of engine load and biodiesel content on performance and regulated and unregulated emissions of a diesel engine using contour-plot map, Science of the Total Environment, 658, 1117–1130, 2019.

Kolakoti, A., Setiyo, M., Waluyo, B., Biodiesel production from waste cooking oil: characterization, modeling and optimization, Mechanical Engineering for Society and Industry, 1(1), 22-30, 2021.

Kumar, B.R., Saravanan, S., Use of higher alcohol biofuels in diesel engines: a review, Renewable and Sustainable Energy Reviews, 60, 84–115, 2016.

Ma, Q., Zhang, Q., Liang, J., Yang, C., The performance and emissions characteristics of diesel/biodiesel/alcohol blends in a diesel engine, Energy Reports, 7, 1016–1024, 2021.

Örs, İ., Sayin, B., Ciniviz, M., Comparative study of ethanol and methanol addition effects on engine performance, combustion and emissions in the SI engine, International Journal Of Automotive Science And Technology, 4(2), 59–69, 2020.

Ortega, M.V., Ochoa, G.V., Forero, J.D., Experimental study of emissions in single-cylinder diesel engine operating with diesel-biodiesel blends of palm oil-sunflower oil and ethanol, Case Studies in Thermal Engineering, 26, 101190, 2021.

Pan, M., Huang R., Liao J., Jia C., Zhou X., Huang H., Huang X., Experimental study of the spray, combustion, and emission performance of a diesel engine with high n-pentanol blending ratios, Energy Conversion and Management, 194, 1–10, 2019.

Perdana, D., Yuliati, L., Hamidi, N., Wardana, I.N.G., The role of magnetic field orientation in vegetable oil premixed combustion, Journal of Combustion, 2020, 2020.

Perdana, D., Adiwidodo, S., Choifin, M., Winarko, W.A., The effect of magnetic field variations in a mixture of coconut oil and jatropha on flame stability and characteristics on the premixed combustion, EUREKA: Physics and Engineering, 5, 13–22, 2021.

Perdana, D., Adiwidodo, S., Subagyo, S., Winarko, W.A., The role of perforated plate and orientation of the magnetic fields on coconut oil premixed combustion, INMATEH - Agricultural Engineering, 67(2), 77–84, 2022.

Perdana, D., Pengaruh variasi arah medan magnet pembakaran premixed minyak nabati terhadap karakteristik nyala api pada tungku industri, Teknik, 43(3), 280–286, 2022.

Portillo, E.A.V., Díaz, B.B., Cervantes, V.Y.M., Life cycle assessment and emission analysis of waste cooking oil biodiesel blend and fossil diesel used in a power generator, Fuel, 281, 118739, 2020.

Qian, Y., Liu, G., Guo, J., Zhang, Y., Zhu, L., Lu, X., Engine performance and octane on demand studies of a dual fuel spark ignition engine with ethanol/gasoline surrogates as fuel, Energy Conversion and Management, 183, 296-306, 2019.

Saikia, M., Thermal and emission performances of citrus maxima biodiesel blends in CI engine, Materialstoday: PROCEEDINGS, 45(6), 4558-4564, 2021.

Soebiyakto, G., Wardana, I.N.G., Hamidi, N., Yuliati, L., Addition of bio-additive as a catalyst of burning vegetable oil influenced by 4 pole magnetic field, Eastern-European Journal of Enterprise Technologies, 2(6–104), 2020.

Suherman, S., Abdullah, I., Sabri, M., Silitonga, A.S., Evaluation of physicochemical properties composite biodiesel from waste cooking oil and schleichera oleosa oil, Energies, 16(15), 5771, 2023.

Tang, Q., Ren, K., Xie, X., Chen, T., Jiang, P., Zhang, D., Impact of acetone-ebutanole-ethanol (ABE) and gasoline blends on the energy balance of a high-speed spark-ignition engine, Thermal Science and Engineering Progress, 46, 102175, 2023.

Taufik, M., Perdana, D., Effect of mixture eucalyptus oil and magnetic fields on droplets combustion palm oil on flame behaviours and flue gas emissions, Journal of Renewable Energy and Mechanics, 7(01), 1–11, 2024.

Thakur, A.K., Kaviti, A.K., Mehra, R., Mer, K.K.S., Progress in performance analysis of ethanol-gasoline blends on SI engine, Renewable and Sustainable Energy Reviews, 69, 324–340, 2017.

Usman, M., Malik, M.A.I., Bashir, R., Riaz, F., Raza, M.J., Suleman, K., Rehman, A.U., Ashraf, W.M., Krzywanski, J., Enviroeconomic assessment of HHO-CNG mixture utilization in spark ignition engine for performance and environmental sustainability, Energies, 15(21), 8253, 2022.

Verma, P., Stevanovic, S., Zare, A., Dwivedi, G., Chu, T.V., Davidson, M. Davidson., Rainey, T., Brown, R. J., Ristovski, Z.D., An overview of the influence of biodiesel, alcohols, and various oxygenated additives on the particulate matter emissions from diesel engines, Energies, 12(10), 1987, 2019.

Wiratmaja, I.G., Elisa, E., Kajian peluang pemanfaatan bioetanol sebagai bahan bakar utama kendaraan masa depan di indonesia, Jurnal Pendidikan Teknik Mesin Undiksha, 8(1), 1–8, 2020.

Wu, G., Ge, J.C., Choi, N.J., Effect of ethanol additives on combustion and emissions of a diesel engine fueled by palm oil biodiesel at idling speed, Energies, 14(5), 1428, 2021.

Yaqoob, H., Teoh, Y.H., Sher, F., Farooq, M.U., Jamil, M.A.., Kausar, Z., Sabah, N.U., Shah, M.F., Rehman, H.Z.U., Rehman, A.U., Potential of waste cooking oil biodiesel as renewable fuel in combustion engines: a review, Energies, 14(9), 2565, 2021.

Zhang, Z., Wei, Z., Experiment and simulation of the effects of non-uniform magnetic field on the regression rate of PMMA, Combustion and Flame, 223, 337-348, 2021.

DOI: https://doi.org/10.29303/dtm.v14i2.924